Precautions for fire prevention of fuel tanker truck trailer!
45000liters fuel tanker trailer
Fuel tanker truck trailer can transport petrol and diesel, there are carbon steel, stainless and aluminum material tank body depend on customer transport demand. Before refueling operation, the electric pole must be inserted into the wet ground, and the oil transport vehicle should connect the ground with the ground tape. In the process of operation, the conductive static electricity should always be good.
Precautions for fire prevention of fuel tanker truck trailer 1. Do not pour gasoline into the carburetor nozzle while the engine is running or when the fuel tanker truck trailer is rocking. Filling the carburetor with gasoline to increase the concentration of the mixture in the cylinder will help start the carburetor in the event of a failure to enter the cylinder, but it will not help other causes of failure, and it may cause backfire, burn people and burn down vehicles. 2. When maintaining gasoline filter, it is not recommended to burn gasoline filter core. Many people in the maintenance of gasoline filters, like to use gasoline burning ceramic filter element method to remove impurities on the filter element. The hazard of doing so is that it is easy to catch fire and has an impact on the life of the filter element. 3. in the oil depot, do not use short-circuit fire to check the battery storage situation. Because in a small oil depot with poor ventilation, tires, batteries, tarpings and other equipment are often placed. There is spilled gasoline on the ground, which is likely to ignite the oil molecules in the air due to the sparks generated when the fire is scraped. 4. the tanker mop floor chain must not be entangled in the beam. Oils, like other substances, produce static electricity when they rub against another object. This static electricity jumps the fire, which can ignite the fuel and start a fire. Therefore, grounding wire should be installed on the oil depot, and a grounding iron chain should be installed on the oil tanker to prevent the generation of electrostatic sparks in the tank. The iron chain should not be randomly wrapped around the girder frame, but must be placed on the ground and towed to no less than 50 cm. 5. Fuel is strictly prohibited under the high voltage wire. 6. Do not often use fire hanging method. Sometimes have a coke, spark plugs when a cylinder of carbon deposition is serious, the cylinder can't work normally, in order to make the cylinder can run normally, adopt the method of hanging fire outside the cylinder (will spark plugs and the high tension line between a 3 mm to 4 mm gap), to improve the spark plug electrode spark over energy, restore the cylinder to work, but generally slightly do not pay attention to "hanging fire" method is easy to fall off. If there is dripping petrol on the cylinder block, it is very likely to cause a fire. It is therefore only a temporary remedy. Correct treatment should be timely cleaning and maintenance of spark plugs, try to avoid the use of hanging fire method. 7. Do not allow leakage of the automobile oil system.If the chassis part of the oil leakage, and is in the ignition late point, dilute mixture point, because the slow combustion will make the exhaust pipe flame, the body temperature, more than ten times the ignition point of gasoline vapor (gasoline vapor ignition point is 28℃). The leaking oil will ignite, easy to cause fire, resulting in the scrapping of the car body.If the carburetor part drips on the cylinder head, the spark plug high voltage spark leakage may also cause a fire.